供應電氣化鐵路線索測力儀-彈性吊索張力測試儀-銅絞線拉力檢測儀-線索測力儀

供應電氣化鐵路線索測力儀-彈性吊索張力測試儀-銅絞線拉力檢測儀-線索測力儀

一、
供應電氣化鐵路線索測力儀-彈性吊索張力測試儀-銅絞線拉力檢測儀-線索測力儀
Supply electrified railway clues - elastic suspension tension tester - copper strand tension detector - clue dynamometer主要用途及使用范圍
I. main purpose and scope of use
適用于電力行業、橋梁、煤礦行業、通信行業、交通運輸行業、玻璃墻幕裝飾行業、索道運行業、建筑行業、游樂場所、隧道施工、漁業捕撈與各大科研院所和教學機構、檢測機構及涉及到鋼索、繩索和鋼絲繩拉力的場合。

供應電氣化鐵路線索測力儀-彈性吊索張力測試儀-銅絞線拉力檢測儀-線索測力儀
Supply electrified railway clues - elastic suspension tension tester - copper strand tension detector - clue dynamometer
Applicable to electric power industry, Bridges, coal industry, communications industry, transportation industry, glass wall curtain decoration industry, ropeway transport industry, construction industry, the amusement place, the tunnel construction, fishing and major scientific research institutes and teaching institutions, testing institutions and involves the wire, ropes, and the occasion of wire rope tension.
二、主要功能特點
Ii. Main functional features
具有張緊力的繩索結構，不需拆卸即可直接測量。重量輕、結構簡單、操作方便，適用于任何場合。具有七種線徑測量功能、測量范圍更寬、節省成本。使用范圍：適用于柔性的，拉伸的索。如各種鋼絲繩、度繩索等等……。精度等級：±3%～6%（取決于繩索形式和特點）當被測索規格與測力儀中儲存索號規格相同時，在額定量程內/測力精度可達±2％。繩索直徑：10mm～22mm。測試量程：10T。
A rope with tensioning force can be directly measured without disassembly. Light weight, simple structure, convenient operation, suitable for any occasion. It has seven diameter measuring function, wider range of measurement and cost saving. Scope of use: applicable to flexible, stretched cables. A variety of wire ropes, high strength ropes and so on... . Accuracy grade: + / -3% ~ 6% (depending on the form and characteristics of the rope) when the cable specification and the storage cable in the measuring instrument are in the same time, the accuracy of the rated range/measuring force can be up to or minus 2%. Rope diameter: 10mm ~ 22mm. Test range: 10T.
顯示價格均為參考價，請聯系銷售人員詢價。
The display price is the reference price. Please contact the salesman for an inquiry.
供應電氣化鐵路線索測力儀-彈性吊索張力測試儀-銅絞線拉力檢測儀-線索測力儀
Supply electrified railway clues - elastic suspension tension tester - copper strand tension detector - clue dynamometer
不同量程索力測定儀標定的索號如下表：
The following table of the cable of different range sorter calibration is as follows:
SL—10 SL—20 SL—30
SL - 10-20 SL SL - 30
索號 直徑
No. Cable diameter
mm 量程（T） 索號 直徑
Mm range (T)
mm 量程 （T） 索號 直徑
Mm range (T)
mm 量程（T）
Mm range (T)
1 φ10 5 1 φ≤16 10 1 φ≤22 15
1 phi, 10, 5, 1 phi is less than 16, 10, 1 phi is less than 22, 15
2 φ12 5 2 φ18 10 2 φ24 15
2 phi 12 5 2 phi 18 10 2 phi 24 15
3 φ14 10 3 φ20 15 3 φ26 20
3 phi 14 10 3 phi 20 15 3 phi 26 20
4 φ16 10 4 φ22 15 4 φ28 20
4 phi 16 10 4 phi 22 15 4 phi 28 20
5 φ18 10 5 φ24 20 5 φ30 30
5 phi 18 10 5 phi 24 20 5 phi 30 30
6 φ20 10 6 φ26 20 6 φ32 30
6 phi 20 10 6 phi 26 20 6 phi 32 30
7 φ22 10 7 φ28 20 7 φ34 30
7 phi 22 10 7 phi 28 20 7 phi 34 30
保養注意事項
Maintenance precautions
⑴鋼絲繩的使用期限與使用方法有很大的關系，因此應做到按規定使用，禁止拖拉、拋擲，使用中不準超負荷，不準使鋼絲繩發生銳角折曲，不準急劇改變升降速度，避免沖擊載荷。
The improvement of the service life of the wire rope and the use method has a lot to do, so should be used according to regulations, it is prohibited to drag, casting, using the overload is not allowed, no acute twist in the cable, not allowed to change sharply lifting speed, avoid impact load.
⑵鋼絲繩有鐵銹和灰垢時，用鋼絲刷刷去并涂油。
When the wire rope has rust and ash, brush with steel wire and oil.
⑶鋼絲繩每使用4個月涂油一次，涂油時好用熱油（50℃左右）浸透繩芯，再擦去多余的油脂。
(3) wire rope oiled every using 4 months time, had better use hot oil when the oil (about 50 ℃) cable, soak, then wipe away excess oil.
⑷鋼絲繩盤好后應放在清潔干燥的地方，不得重疊堆置，防止扭傷。
The wire rope should be kept in a clean and dry place, not overlapped, preventing sprain.
⑸鋼絲繩端部用鋼絲扎緊或用熔點低的合金焊牢，也可用鐵箍箍緊，以免繩頭松散。
The end of the wire rope ends with a wire or a low-melting alloy, which can also be used to tighten the hoop, so that the rope head is not loose.
⑹使用中，鋼絲繩表面如有油滴擠出，表示鋼絲繩已承受相當大的力量，這時應停止增加負荷，并進行檢查，必要時更換新鋼絲繩。
In the case of use, the steel wire rope has been squeezed out of the surface of the wire rope, which indicates that the steel wire rope has been subjected to considerable force, so it should stop increasing the load and check it, and replace the new steel wire when necessary.
⑺牽引鋼絲繩的承載能力應為總牽引力的5—8倍。
The carrying capacity of the steel wire rope is 5 to 8 times that of the total traction.
供應電氣化鐵路線索測力儀-彈性吊索張力測試儀-銅絞線拉力檢測儀-線索測力儀
Supply electrified railway clues - elastic suspension tension tester - copper strand tension detector - clue dynamometer